小型混凝土搅拌机的发动机在使用的时候需要注意什么问题，我们应该怎样维护？下面就针对这两方面内容，小编为您做解答。

What problems should we pay attention to when using the engine of small concrete mixer, and how should we maintain it? Here are the answers to these two aspects.

一，使用搅拌机发动机时的注意事项

1、 Precautions when using mixer engine

1.进行新机器或大修后，柴油发动机无法从一开始就充满负荷并无法高速运转。在转换为正常操作之前，它应在低速和轻载下运行50小时。

1. After a new machine or overhaul, the diesel engine cannot be fully loaded from the beginning and cannot run at high speed. Before switching to normal operation, it shall operate at low speed and light load for 50 hours.

2.确保燃油清洁。如有必要，通过沉淀物或丝绸过滤。

2. Make sure the fuel is clean. If necessary, filter through sediment or silk.

3.保持正常的水温（70-85°C）和液压（中速0.2-0.4MPa）。

3. Keep normal water temperature (70-85 ° C) and hydraulic pressure (medium speed 0.2-0.4MPa).

4.驾驶中发现异常情况，并立即检查了车辆。

4. If any abnormality is found during driving, check the vehicle immediately.

5.为防止结垢并缩短发动机寿命，建议不要使用“硬水”作为冷却水。

5. In order to prevent scaling and shorten engine life, it is recommended not to use "hard water" as cooling water.

二，小型混凝土搅拌机的定期保养

2、 Regular maintenance of small concrete mixer

1.检查油量计上两条刻线之间顶线附近的油槽的油位。新机器或柴油发动机长时间停机后，在机油加满上线后，以低速停机5-10分钟，并使用量油尺测量机油油位。

1. Check the oil level in the oil tank near the top line between the two scribed lines on the oil gauge. After a new machine or diesel engine has been shut down for a long time, after the engine oil is filled up and online, stop the machine at a low speed for 5-10 minutes, and measure the oil level with the dipstick.

2.检查水箱中的水量。

2. Check the water volume in the water tank.

3.检查喷油泵的油位。如果不是，则需要将其添加到该位置。

3. Check the oil level of fuel injection pump. If not, you need to add it to the location.

4.三个泄漏（油，水，气）。

4. Eliminate three leaks (oil, water and gas).

5.检查组件和附件的坚固性。

5. Check the robustness of components and accessories.

6.检查清洁状态，除油和除尘，特别注意电气设备的干燥和清洁。

6. Check the cleaning status, remove oil and dust, and pay special attention to the drying and cleaning of electrical equipment.

7.新机器在轻负载下运行50小时后，应及时更换机油（包括燃油喷射泵中的机油）和机油滤清器部件，并清洁油底壳和机油滤清器。

7. After the new machine runs for 50 hours under light load, replace the engine oil (including the engine oil in the fuel injection pump) and engine oil filter components in time, and clean the oil pan and engine oil filter.

8.及时保护日常润滑油添加剂。

8. Timely protect daily lubricating oil additives.

以上是关于使用搅拌机发动机的注意以及定期保养事项的问题，关注我们https://www.zishangliaojiaobanji.cn来了解更多相关事项吧！

The above questions are about the precautions for using the mixer engine and the regular maintenance. Pay attention to us https://www.zishangliaojiaobanji.cn Learn more about it!