小型搅拌机驱动装置的作用是驱动混凝土贮罐转动，它由取力器、万向轴、液压泵、液压马达、操纵阀、液压油箱及冷却装置组成。如果这部分因故障停止工作，混凝土贮罐将不能转动，这会导致车内混凝土报废，严重的甚使整罐混凝土凝结在罐内，造成混凝土搅拌运输车报废。所以说小型搅拌机的驱动装置是否可靠很关键。

The driving device of small mixer is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal shaft, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to failure, the concrete storage tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, and even cause the whole tank of concrete to condense in the tank, resulting in the scrapping of the concrete mixer truck. Therefore, whether the driving device of the small mixer is reliable is critical.

1.小型搅拌机削部件是故障部件。应及时填充润滑脂，并经常检查磨损情况，及时修理和更换。车队应该有一个备用的万向轴组件，以确保在发生故障时能够在几分钟内恢复。

1. The cutting parts of small mixer are faulty parts. The lubricating grease shall be filled in time, the wear condition shall be checked frequently, and the repair and replacement shall be carried out in time. The fleet should have a spare cardan shaft assembly to ensure recovery within a few minutes in the event of a failure.

2.确保液压油清洁。搅拌一体车的工作环境不好，须防止脏水泥砂进入液压系统。应根据手册的要求定期更换液压油。一旦检查发现水或沙子混入液压油中，就须立即停止液压系统并更换液压油。

2. Make sure the hydraulic oil is clean. The working environment of the mixer truck is not good, so it is necessary to prevent dirt proof cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the manual. Once water or sand is found to be mixed in the hydraulic oil, the hydraulic system must be stopped immediately and the hydraulic oil must be replaced.

3.确保液压油冷却装置有效。定期清洗液压油散热器，避免散热器被水泥堵住，检查散热器电风扇是否正常运行，防止液压油温度超标。只要液压部件确保液压油清洁，通常几乎没有故障，但制造商具有不同的使用寿命。

3. Ensure that the hydraulic oil cooling device is effective. Clean the hydraulic oil radiator regularly to prevent the radiator from being blocked by cement. Check whether the radiator fan operates normally to prevent the hydraulic oil temperature from exceeding the standard. As long as the hydraulic components ensure that the hydraulic oil is clean, there are usually few failures, but the manufacturers have different service lives.

一般来说，如果小型搅拌机的驱动装置由于故障停止工作，混凝土储罐将不能正常旋转，这将导致车辆中的混凝土报废，甚整个罐体混凝土将在罐内冷凝，造成搅拌一体车要报废。因此，驱动装置是否可靠是在使用中须高度重视的问题。关注我们https://www.zishangliaojiaobanji.cn，带您了解更为详细的内容！

Generally speaking, if the driving device of the small mixer stops working due to failure, the concrete tank will not rotate normally, which will lead to the scrapping of the concrete in the vehicle, or even the whole tank concrete will condense in the tank, resulting in the scrapping of the mixer. Therefore, whether the driving device is reliable is a problem that must be paid great attention to in use. Follow us https://www.zishangliaojiaobanji.cn , to guide you to more detailed content!