小型混凝土搅拌机正常驾驶、不需要远程油门时，须关断远程油门切换开关；远程油门使用完后，请随即关断远程油门切换开关，以保证车辆。等等这类的注意事项要了解到，下面来讲讲该如何用混凝土搅拌机拌制混凝土内容信息吧。

When the small concrete mixer is driven normally and does not need remote accelerator, the remote accelerator switch must be turned off; After using the remote accelerator, please turn off the remote accelerator switch immediately to ensure the safety of the vehicle. We should understand such precautions. Let's talk about how to mix concrete with a concrete mixer.

如何用混凝土搅拌机拌制混凝土？如不借助于搅拌站，而直接用搅拌机搅拌混凝土（湿拌），则请按下述步骤进行：

How to mix concrete with concrete mixer? If concrete (wet mixing) is directly mixed with a mixer without the aid of a mixing station, please follow the following steps:

（1）进料

(1) Feed

先注入总用水量2/3的水；

First inject 2 / 3 of the total water consumption;

接下来，将1/2的粗骨料、1/2的砂、全部的水泥顺次送入拌筒，随后，再将余下的1/2的砂送入；

Next, 1 / 2 of the coarse aggregate, 1 / 2 of the sand and all the cement are sent to the mixing drum in sequence, and then the remaining 1 / 2 of the sand is sent to the mixing drum;

后，将余下的1/2的粗骨料和1/3的水送入。

After that, the remaining 1 / 2 of the coarse aggregate and 1 / 3 of the water are sent.

（2）拌筒转速及搅拌时间

(2) Mixing drum speed and mixing time

进料时拌筒的转速：6～10转/分

Speed of mixing drum during feeding: 6-10 rpm

搅拌时拌筒的转速：6～10转/分

Speed of mixing drum during mixing: 6-10 rpm

搅拌时间：进料后起10～16分钟

Mixing time: 10-16 minutes after feeding

（3）搅动·出料

(3) Stirring and discharging

搅拌完毕后的搅动和出料。

Stirring and discharging after mixing.

（4）注意

(4) Attention

投料时，切忌只投水泥。

When feeding, do not only feed cement.

上述方法仅是一例。由于具体的拌制方法随混凝土种类的不同而有所不同，因此，请根据试拌等的结果，来决定实际采用的方法和数值。

The above method is only one example. As the concrete mixing method varies with the concrete type, please determine the actual method and value according to the results of trial mixing.

在干旱地区，需长途运送预拌混凝土时，为保证混凝土的质量，水是在运送目的地后再加注搅拌的，所以拌车要有大容量水箱才能满足要求。

In arid areas, when long-distance transportation of ready mixed concrete is required, in order to ensure the quality of concrete, the water is added and mixed after being transported to the destination, so the mixer must have a large capacity water tank to meet the requirements.

将混凝土加入拌筒，使拌筒处于旋转状态，发动机转速应控制在550～650r/min。否则在发动机低速转动的场合，使装有预拌混凝土的拌筒运转，往往易导致发动机熄火，且易损伤离合器、轴承（离合器变速箱）等。

The concrete shall be added into the mixing drum to make the mixing drum rotate. The engine speed shall be controlled at 550-650r / min. Otherwise, when the engine is running at a low speed, it is easy to cause the engine to shut down and damage the clutch, bearing (clutch gearbox), etc. if the mixing cylinder with ready mixed concrete is operated.

请注意，在搅拌机驾驶室内，设有远程油门切换开关，当驾驶室脚踏油门起作用时，车尾远程油门将被关闭，不起作用，此时若要在车尾用手柄操纵油门，需按下远程油门切换开关。更多相关事项就来咨询我们https://www.zishangliaojiaobanji.cn吧。

Please note that there is a remote accelerator switch in the cab of the mixer. When the pedal accelerator in the cab works, the remote accelerator at the rear of the vehicle will be closed and will not work. At this time, if you want to control the accelerator with a handle at the rear of the vehicle, you need to press the remote accelerator switch. Please contact us for more information https://www.zishangliaojiaobanji.cn Right.