如今的搅拌机不仅要行驶在蜿蜒的山路上，还要经过车辆集中的市区。由于搅拌机高，行驶困难，而搅拌机运输混凝土的难易程度对整个建筑的质量非常重要。因此，搅拌机司机的责任非常重要，工作中有很多细节要掌握，否则不管什么问题都是很严重的。要注意以下几点：

Today's mixers not only drive on winding mountain roads, but also pass through urban areas where vehicles are concentrated. Due to the high center of gravity of the mixer, it is difficult to drive, and the difficulty of transporting concrete by the mixer is very important to the quality of the whole building. Therefore, the responsibility of mixer driver is very important. There are many details to master in the work, otherwise any problem is very serious. Note the following:

1、搅拌机输送的混凝土的质量和坍落度应符合混凝土行业的标准和要求。

1. The quality and slump of the concrete transported by the mixer shall comply with the standards and requirements of the concrete industry.

2、小型混凝土搅拌机在路上运行时，加长溜槽必须放在卸料溜槽支架上，并用挂钩固定。不允许在主卸料槽上工作。将主卸料槽旋转到固定位置，拉下定位手柄，用锁紧手柄锁紧弹簧变幅机构，避免不固定晃动造成人身伤害等事故。

2. When the small concrete mixer is running on the road, the extended chute must be placed on the support of the discharge chute and fixed with hooks. It is not allowed to work on the main discharge chute. Rotate the main discharge chute to the fixed position, pull down the positioning handle, and lock the spring luffing mechanism with the locking handle to avoid personal injury and other accidents caused by unstable shaking.

3、安装在搅拌机上的设备的连续工作时间不应超过8小时。

3. The continuous working time of the equipment installed on the mixer shall not exceed 8 hours.

4、在混凝土运输过程中，不能停止大型搅拌机的加料罐，否则混凝土会凝结。当液压系统和减速器停机后重新启动时，液压系统和减速器会受到冲击，造成液压泵和马达的损坏。

4. During the concrete transportation, the feeding tank of the large mixer shall not be stopped, otherwise the concrete will set. When the hydraulic system and reducer are restarted after shutdown, the hydraulic system and reducer will be impacted, causing damage to the hydraulic pump and motor.

5、搅拌机料时，如发现混凝土水分蒸发过多，坍落度低，达不到质量要求，可适当加水罐内，然后以10转卸车前-14rpm30分钟，使混凝土充分混合。

5. During mixing, if it is found that the water evaporation of concrete is too much, the slump is low, and the quality requirements cannot be met, water can be added to the tank appropriately, and then -14rpm30 minutes before unloading at 10 turns to fully mix the concrete.

6、搅拌机在空载时不能停车，否则行驶过程中车辆的晃动很容易造成滚道与滚子相撞，导致滚子与滚道过早损坏。

6. The mixer shall not be stopped when it is unloaded, otherwise the rolling path and roller may collide due to the shaking of the vehicle during driving, resulting in premature damage of the roller and roller path.

7、搅拌机司机切记，工作过程中一定要经常加满压力水箱的水，加满水箱前要打开气阀，冲洗完水箱内的空气要放掉。或停车。冬季工作结束后，应将水箱内的水排干，不能有积水，否则容易结冰损坏水箱。

7. The mixer driver should keep in mind that the water in the pressure water tank must be filled frequently during the working process, the air valve must be opened before filling the water tank, and the air in the water tank must be discharged after flushing. Or stop. After the winter work, the water in the water tank shall be drained without ponding, otherwise it is easy to freeze and damage the water tank.

8、小型混凝土搅拌机装满混凝土时，罐体正转。如果需要倒车，必须等到水箱停止后，再将把手拉到倒车位置。

8. When the small concrete mixer is full of concrete, the tank rotates forward. If you need to reverse, you must wait until the water tank stops, and then pull the handle to the reverse position.

司机在搅拌机操作中需要注意的事情在此讲解了八点，这是司机应该要做到的责任，只有严格遵守才能让机器更好的完成工作，才能让周围人员的受到保障。您可以来关注我们网站www.zishangliaojiaobanji.cn，咨询了解更多事项。

Here are eight points that the driver should pay attention to during mixer operation. This is the responsibility of the driver. Only by strictly abiding by it can the machine better complete the work and ensure the safety of the surrounding personnel. You can follow our website www.zishangliaojiaobanji Cn for more information.