混凝土搅拌机作为搅拌能力强大的混凝土搅拌设备，在安装时若是不牢靠或部件不标准，很可能会发生问题，所以在安装完毕后需要认真检验，是否安装合格。检验混凝土搅拌机是否安装合格的方式是怎样的？

As a concrete mixing equipment with strong mixing capacity, if the concrete mixer is not reliable or the parts are not standard during installation, it is likely to have safety problems, so it needs to be carefully inspected after installation to see whether the installation is qualified. What is the way to check whether the concrete mixer is installed and qualified?

（1）固定式搅拌机，应设置在结实的台座上，若长期使用，应埋设地脚螺栓，若短期使用，应在机下铺设木枕并找平放稳。

(1) The fixed mixer should be set on a solid pedestal. If it is used for a long time, anchor bolts should be buried. If it is used for a short time, wooden pillows should be laid under the machine and leveled and placed stably.

（2）移动式搅拌机，应设置在平整坚固的地坪上，用木方或支持架架牢，并保持水平，严禁以轮胎替代支持，使用时间较长的（一般超过3个月的）应将轮胎卸下妥善保管，轮轴端部应做好清洗和防锈作业。

(2) The mobile mixer should be set on a flat and solid floor, firmly supported by wood or support frame, and kept horizontal. It is strictly forbidden to replace the support with tires. The tires that have been used for a long time (generally more than 3 months) should be removed and properly stored. The axle ends should be cleaned and rust proof.

（3）传动组织、作业设备、离合器、制动器，均应紧固，灵活牢靠，防护罩完整。

(3) The transmission organization, operation equipment, clutch and brake shall be fastened, flexible and reliable, and the protective cover shall be complete.

（4）小型混凝土搅拌机的钢丝绳不得有锈蚀、断丝、压扁等情况。

(4) The steel wire rope of the small concrete mixer shall not be rusted, broken, flattened, etc.

（5）机体上稳定挂钩，料斗上吊耳应无缺，当料斗升起时，应挂上稳定妥钩。

(5) The stable hook on the machine body and the lifting lug on the hopper should be intact. When the hopper is raised, the stable hook should be hung.

（6）对需挖设上料斗地坑的搅拌机，其坑口周围应以垫高夯实，上料轨迹架的底端面也应夯实或铺砖架的后边应用木材加以支持以避免作业时间长，轨迹变形。

(6) For the mixer that needs to excavate the hopper pit, the pit mouth should be padded and compacted, the bottom end face of the loading track frame should also be compacted, or the back of the brick laying frame should be supported with wood to avoid long operation time and track deformation.

（7）搅拌机应设防雨棚，机械周围无泥水，干净整齐，各种牌示完整。

(7) The mixer shall be provided with a rain proof shed, and there shall be no muddy water around the machine, which shall be clean and tidy, and all kinds of signs shall be complete.

（8）搅拌机应设置“一机一闸一漏一箱”，漏电维护器参数为30MA×0.1S，电机绝缘电阻值应大于0.5MΩ；维护零线不少于两处，操作台外表、指示信号精确牢靠。

(8) The mixer shall be set with "one machine, one switch, one leakage and one box", and the parameter of leakage maintainer is 30mA × 0.1s, the insulation resistance of the motor should be greater than 0.5m Ω; Maintain at least two zero lines, and the appearance of the console and the indication signal are accurate and reliable.

以上就是对如何检验混凝土搅拌机是否安装合格的介绍，想要了解更多关于该设备相关的信息，就来关注我们网站https://www.zishangliaojiaobanji.cn咨询客服人员解答疑问吧。

The above is an introduction to how to check whether the concrete mixer is qualified. If you want to know more about the equipment, please follow our website https://www.zishangliaojiaobanji.cn Consult customer service personnel to answer questions.